AR /OPNAVINST A/MCO Joint Regulation Governing the Use and Application of Uniform Source Maintenance. AR –82/SECNAVINST /AFMAN 21– This regulation contains internal control provisions in accordance with AR 11–2 and identifies key internal . AR JOINT REGULATION GOVERNING THE USE AND APPLICATION OF UNIFORM SOURCE MAINTENANCE AND RECOVERABILITY CODES.
|Published (Last):||8 February 2017|
|PDF File Size:||5.98 Mb|
|ePub File Size:||12.66 Mb|
|Price:||Free* [*Free Regsitration Required]|
Authorized maintenance that can restore an item to operating condition ready for use from one or more, but not all of its identified failure modes at one LOM activity, but requires progressively higher LOM activities until the highest level alone can restore the item to operating 7000-82 from any and all identified failure modes. Code entered in the sixth position of the uniform format used to convey specific information to the logistic community and to the operating forces.
Air Force Handbook 23—, Volume 1. However, mobility or 700-2 requirements may override the economics.
In the unlikely event that two different Service option codes apply to the same 700-8, the P progressive maintenance code will take precedence. USAF organizational-level maintenance activities 70-82 under the two-level maintenance concept may perform limited intermediate-level maintenance and condemn items indicated by recoverability Code F in the fifth position of the SMR code.
Codes assigned to a specific support item for a particular application to an end item may also vary when the end. Item is not procured or stocked because the requirements for the item will result in the replacement of the next higher assembly. Support item excluding support equipment, procured for initial issue or outfitting and stocked only for subsequent or additional initial issues or out-fittings.
Navy, and the U. A series source codes.
Army Publishing Directorate
Materiel Management Reference Information Available at http: Appendix D Maintenance Codes D—1. Consumable or expendable item A non-repairable item or repair part, which can be discarded more economically than it can be repaired or which is consumed in use.
PF Support equipment which will not be stocked, but which will be centrally procured on demand. Military Services and PAs may delegate coding responsibility to the procuring military Service or PA by mutual written agreement. MH Item to be manufactured or fabricated at intermediate maintenance activity. The servicing method in which an already-repaired piece of equipment is exchanged for a failed piece of equipment, which in turn is repaired and kept for another exchange.
Purpose This regulation establishes uniform source, maintenance, and recoverability SMR codes for all Department of Defense DOD Services and participating agencies PAs and prescribes policy and interprets guidelines for the initial assignment, changes to, and application of these codes. Upon approval of the SMR code, no changes to the coding that affect the recoverability for example, spare to repair part or repair part to spare will be implemented without a review of the life cycle cost impact considering all required support resources.
When item becomes unserviceable, condemn and disposed of by authorized activity. Air Force Instruction 23— Marine Corps programs throughout. It requires that all maintenance capabilities for example, remove, replace, repair, assemble, and test for the support item be provided at that level.
Organic sources should be reviewed when commercial sources cannot meet demand. It requires that all logistics support for example, parts, publications, tools, and test equipment be provided to that activity to perform all assigned maintenance functions or tasks. The lowest maintenance level capable of complete repair of the support item is the depot activity.
Marine Corps terminologies to reflect currentorganizational structures throughout. General source, maintenance, and recoverability coding policy a. Support item with low mortality rate, not stocked. Recoverability Codes, page PG Item procured and stocked to provide for sustained support for the life of the equipment.
Codes entered in the third and fourth positions of the uniform code format see ad D are as follows:. X series source coded items are items for which no demand is anticipated see table C—5.
Policy, Implementation, and Format. M 700–82 source codes. Service option codes entered in the sixth position of the uniform SMR format are listed at table F—1 and table F—2. The proponent has the authority to approve exceptions or waivers to this regulation that are consistent with controlling law and ae.
Recoverability codes are assigned to support items to indicate the disposition action on unserviceable xr. PD Support item excluding support equipment, procured for initial issue or outfitting and stocked only for subsequent or additional initial issues or out-fittings.
No parts or special tools are procured for the maintenance of this item. A concise description of a strategy for achieving, maintaining, and restoring the operational capability of a weapon system and equipment.
However, because of Service differences in communicating maintenance 70-82 level information a maintenance code entry in this position is not 700–82 by all Services. X series source codes X series source coded items are items for which no demand is anticipated see table C—5. Inserted when the maintenance code is not used.
Codes assigned to end items and support items to indicate the manner of acquiring items for the maintenance, repair, or overhaul of end items. Source codes are assigned to support items to indicate the manner of acquiring support items for maintenance, repair, rework, or overhaul of end items and to identify items requiring special handling for example, hazardous and precious materials.
The proponent may delegate this approval authority, in writing, to a division chief within the proponent 700-28 or its direct reporting unit or field operating agency, in the grade of colonel or the civilian equivalent. Fifth position The recoverability code is entered in the fifth position of the uniform SMR code format see table E—1.